Common Specs & Procedures
iQ COMMON SPECS & PROCEDURES
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Front | 159 ft.lbs (216 N.m) | ||
| Rear | 66 ft.lbs (90 N.m) | ||
| Battery | SERVICE DATA | ||
| Brakes | |||
| Bleeding Sequence | BLEEDING | ||
| Disc/Drum Brakes | Front: SERVICE DATA Rear: SERVICE DATA |
||
| Torque | Front: TORQUE SPECIFICATIONS Rear: TORQUE SPECIFICATIONS |
||
| Charging | |||
| Generator | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | INSTALLATION | ||
| Belt Routing | INSTALLATION | ||
| Engine Cooling | |||
| General Service Specifications | SERVICE DATA | ||
| Radiator Cap Pressure | New Cap: 93.3 to 122.7 kPa (0.95 to 1.25 kgf/cm2
, 13.5 to 17 psi) Used Cap: 78.5 kPa (0.80 kgf/cm2 , 11.38 psi |
||
| Thermostat R & I | THERMOSTAT | ||
| Water Pump R & I | WATER PUMP | ||
| Engine Mechanical | |||
| Compression | SERVICE DATA | ||
| Oil Pressure (176°F (80°C) | 30 kPa (.3 kgf/cm2
, 4.4 psi) or higher @ idle 150 to 550 kPa (1.5 to 5.6 kgf/cm2 , 22 to 80 psi) @ 3000 RPM |
||
| Overhaul | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. | ||
| Flywheel/Drive Plate Torque | 88 N. m (65 ft.lbs) | ||
| Fuel System | |||
| Pressure Specification | 304-343 kPa (3.1-3.5 kgf/cm2 , 44-50 psi) | ||
| Fuel Pressure Test Procedure | ON-VEHICLE INSPECTION | ||
| Fuel Filter | FUEL PUMP | ||
| Ignition | |||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Spark Plug (DENSO: SC20HR11) | |||
| Gap | 1.0-1.1 mm (.039-.043 in.) | ||
| Torque | 20 N.m (15 ft. lbs.) | ||
| Starting | |||
| Starter | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | |||
| Front | SERVICE DATA | ||
| Rear | SERVICE DATA | ||
| Torque | |||
| Front | TORQUE SPECIFICATIONS | ||
| Rear | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 103 N.m (76 ft. lbs.) | ||