LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2008 >> Optra LT, Standard >> Repair and Diagnosis >> Engine Performance >> System >> Engine Controls And Fuel - 1.8L (L79) >> Diagnostic Information and Procedures >> Fuel Pump Electrical Circuit Diagnosis >> Component Testing

Component Testing

  1. Remove the fuel pump relay from the electrical center with the J 43244  relay puller pliers.
  2. Test for 70-110 ohms of resistance between terminals 85 and 86.
    • If not within the specified range, replace the relay.
  3. Test for infinite resistance between the following terminals:
    • 30 and 86
    • 30 and 87
    • 30 and 85
    • 85 and 87
    • If not the specified value, replace the relay.
  4. Install a 20A fused jumper wire between relay terminal 85 and 12 volts. Install a jumper wire between relay terminal 86 and ground. Test for less than 2 ohms of resistance between terminals 30 and 87.
    • If greater than the specified range, replace the relay.
scientia non olet · About LEMON Manuals