Steering And Wheel Alignment -- Repair (F44)

• 32 00 Wheel Alignment
  • General chassis definitions
  • General information and definitions
  • Identification of suspension without label
  • KDS data statuses
  • Notes and specifications for the replacement of the steering gear, steering column and the steering shaft following accident damage
  • 32 00 150 Kinematics Diagnosis System wheel alignment with vehicle load up to design position
    • Perform chassis alignment check
  • 32 00 155 Kinematics Diagnosis System wheel alignment with ride height measurement without loading the vehicle
    • Perform chassis alignment check
  • 32 00 601 Adjusting toe-in on front axle
    • Adjusting toe-in on front axle
  • 32 00 620 Adjusting rear axle
    • Adjusting camber (eccentric screw already replaced)
    • Adjusting the toe (screws already replaced)
  • 32 00 621 Adjusting rear axle and replacing with eccentric screws
    • Adjusting camber
    • Adjusting track
• 32 11 Steering Gear Boot
  • Notes on checking the steering backlash on vehicles with rack and pinion steering
  • 32 11 100 Replacing bellows for steering box on left or right
    • Replacing bellows
• 32 13 Electric Power Steering Unit
  • 32 13 070 Removing and installing electric steering box (EPS)
    • Removing the steering gear
    • Checking steering gear and connections for damage
    • Installing the steering gear
  • 32 13 572 Replace electrical steering box (EPS) (after vehicle diagnosis)
    • Replace steering gear
    • Check connections of the steering system for damage
  • 32 13 905 Commissioning / initialization of electromechanical steering gear (EPS) (after vehicle diagnosis)
    • Commissioning (initialization) of the electromechanical steering
• 32 21 Tie Rods, Tie Rod Ends
  • 32 21 151 Replacing left or right tie rod end
    • Replace tension rod end
  • 32 21 231 Replacing left or right tie rod
    • Replacing the tie rod
• 32 31 Steering Column
  • 32 31 004 Removing and installing/replacing steering column shroud upper section
    • Removing steering column shroud upper section
    • Fit steering column shroud upper section
  • 32 31 020 Remove and install/replace lower part of steering column shroud
    • Remove lower part of steering column shroud
    • Install steering column shroud lower section
  • 32 31 070 Removing and installing/replacing lower part of steering shaft
    • Remove lower part of steering shaft
    • Installing steering shaft, bottom
  • 32 31 091 Replace steering column
    • Replacing the steering column
• 32 33 Steering Wheel
  • 32 33 001 Removing and installing the steering wheel
    • Remove steering wheel
    • Install steering wheel
  • 32 33 005 Replace steering wheel
    • Remove steering wheel
    • Removing the steering wheel cover
    • Removing the wiring harness of the steering wheel
    • Installing the wiring harness of the steering wheel
    • Installing the steering wheel cover
    • Greasing the SZL
    • Install steering wheel
  • 32 33 010 Removing and installing the sports steering wheel
    • Remove steering wheel
    • Install steering wheel
  • 32 33 015 Replacing the sports steering wheel
    • Remove steering wheel
    • Removing the steering wheel cover
    • Removing the wiring harness of the steering wheel
    • Installing the wiring harness of the steering wheel
    • Installing the steering wheel cover
    • Install steering wheel
  • 32 33 020 Replacing the M Sport steering wheel
    • Removing the M Sport steering wheel
    • When the airbag unit has been actuated (M Sport steering wheel): Replace the steering wheel and horn plate
    • Installing the M Sport steering wheel
• 32 34 Driver's Front Airbag
  • 32 34 030 Removing and installing/replacing airbag unit
    • Remove airbag unit
    • Install airbag unit
• 32 41 Clips For Rubber Boot
  • Notes for removing and installing ear clips